Product ID:DUBL-CHEK PENETRANTS RC50
MSDS Date:05/01/1987
FSC:6850
NIIN:01-268-6711
MSDS Number: BPCFD

Emergency Phone: 213-861-6324

Info Phone: 213-861-6324

Cage: 21405

Telephone: 562-861-6324/FAX 923-8370

Cage: 21405

MIXTURE ESTERS, PHOSPHATE/PHTHALATE ( CAS NOS. 27961-21-5

HYDROTREATED MIDDLE PETROLEUM DISTILLATE

CAS: 64742-46-7

RTECS: JN9379645

OSHA PEL 5MG/M3

ACGIH TLV: 5MG/M3

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE, SKIN, RESPIRATORY TRACT
IRRITATION. INHALATION MAY CAUSE LIGHT HEADEDNESS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE, SKIN, GASTROINTESTINAL & RESPIRATORY TRACT
IRRITATION SUCH AS TEARING, RASH, NAUSEA OR DIFFICULTY IN
BREATHING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, STOMACH OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELID. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH SOAP &
WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL ADVICE.
INHALATION: REMOV E TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION
IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point Method:COC
Flash Point:200F,93C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.

Spill Release Procedures:SMALL SPILL: WIPE/SOAK UP WITH PAPER TOWEL OR
INERT ABSORBENT. PUT IN DISPOSAL CONTAINER. LARGE SPILL: ELIMINATE
SOURCES OF IGNITION, EVACUATE AND VENTILATE AREA. DIKE TO RETAIN
RUN OFF. VACUUM UP OR PUMP FREE LIQUID INTO DOT SALVAGE CONTAINER.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.DO NOT CUT OR WELD
Other Precautions:DO NOT INGEST. USE WITH ADEQUATE VENTILATION. DO NOT
BREATHE VAPOR OR MIST. DO NOT GET IN EYES. WASH THOROUGHLY AFTER
HANDLING AND BEFORE EATING, DRINKING OR SMOKING. AVOID REPEATED OR
PROLONGED CONTA CT WITH SKIN OR EYES.

Respiratory Protection:WEAR A NIOSH/MSHA APPROVED RESPIRATOR IF
VENTILATION DOES NOT MAINTAIN INHALATION EXPOSURES BELOW PEL/TLV.
WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR HIGH LEVELS
OF CONTAMINATES.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS REQUIRED. LOCAL EXHAUST
RECOMMENDED FOR USE IN ENCLOSED AREAS.
Protective Gloves:NEOPRENE OR NATURAL RUBBER GLOVES
Eye Protection:SAFETY GLASSES - CHEMICAL SPLASH GOGGLES
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES.
LAUNDER CONTAMINATED CLOTHING BEFORE WEARING. WASH BEFORE EATING.
DO NOT SMOKE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. DO NOT INGEST. READ PRECAUTIONS ON
LABEL BEFORE USE.

HCC:V4
Boiling Pt:B.P. Text:440F,227C
Spec Gravity:0.90
Solubility in Water:SLIGHTLY MISCIBLE
Appearance and Odor:YELLOW, GREEN LIQUID, PETROLEUM ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS UPON COMBUSTION.

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.